Product ID:LOW VOC RUSTY MTL PRI 9703131, V7769 830
MSDS Date:06/11/1997
FSC:8010
NIIN:00N091235
Status Code:A
MSDS Number: CJJSF

RUST-OLEUM CORPORATION

11 HAWTHORNE PARKWAY
VERNON HILLS, IL 60061
US

Emergency Phone: 847-367-7700

Info Phone: 847-367-7700

Preparer: LJW

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1800 MG/M3;1000 PPM

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TALC; (MAGNESIUM SILICATE)

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL see Table Z-3

ACGIH TLV: 2 MG/M3

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

ACGIH TLV: 1900 MG/M3;800 PPM

LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM); (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

ETHYLBENZENE

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOBUTANE

CAS: 75-28-5

RTECS: TI4300000

DIPROPYLENE GLYCOL

CAS: 110-98-5

RTECS: UB8785000

2); (COBALT DRIER)

CAS: 136-52-7

LD50 LC50 Mixture:SEE INGS 2,3,6,7,8 & 10
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE CONT: CAUSES IRRIT. SKIN
CONT: SUBSTANCE MAY CAUSE SLIGHT SKIN IRRIT. PROLONGED/ REPEATED
CONT MAY CAUSE SKIN IRRIT. INHALATION: HARMFUL IF INHALED. HIGH
GAS, VAP, MIST OR DUST CONCS MAY BE HARMFUL IF INHALED. AVOID
BREATHING VAPS/MISTS. HIGH VAPOR CONCS ARE IRRITATING TO EYES,
NOSE, THROAT AND LUNGS. INGESTION: SUBSTANCE MAY BE HARMFUL IF
SWALLOWED. ASPIR HAZARD IF SWALLOWED; CAN ENTER LUNGS AND CAUSE
DMG. CHRONIC: MAY CAUSE CNS DISORDERS (E.G., NARCOSIS INVOLVING
LOSS OF COORDINATION, WEAK, FATG, MENTAL CONFUSION, & BLURRED
VISION) AND/OR DMG. OVEREXP TO XYLENE IN LAB ANIMALS HAS BEEN
ASSOC (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: W/LIVER ABNORM, KIDNEY, LUNG, SPLEEN
& EYE DMG AS WELL AS ANEMIA. EFTS IN HUMANS HAVE INCLUDED LIVER &
CARD ABNORM. OVEREXP TO TOLUENE IN LAB ANIMALS HAS BEEN ASSOC
W/LIVER ABNORM, KIDNEY, L UNG & SPLEEN DMG. EFTS IN HUMANS HAVE
INCLUDED LIVER & CARD ABNORMALITIES. TOLUENE APPEARS ON NAVY
LISTING OF OCCUP CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION
FROM APPROP HEALTH PROFESSIONALS CO NCERNING LATEST HAZARD LIST
INFO & SAFE HANDLING AND EXPOSURE INFORMATION .

First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYE CONT: HOLD EYELIDS APART &
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. S KIN CONT: WASH W/SOAP AND WATER. GET MEDICAL ATTENTION
IF IRRITATION DEVELOPS OR PERSISTS. INGESTION: ASPIRATION HAZARD.
DO NOT INDUCE VOMITING OR GIVE ANYTHING BY MOUTH BECAUSE THIS
MATERIAL CAN ENTE R THE LUNGS AND CAUSE SEVERE LUNG DAMAGE. GET
IMMEDIATE MEDICAL ATTENTION.

Flash Point:<-6.7C, 20.F
Lower Limits:1.0%
Upper Limits:12.6%
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . EVACUATE AREA AND FIGHT FIRE FROM A SAFE DISTANCE.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM LIQ & VAP! WATER SPRAY
MAY BE INEFTIVE. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT DUE TO BUILDUP OF STEAM. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT. VAPS MAY FOR M EXPLO MIX W/AIR. VAPS CAN TRAVEL TO
SOURCE OF IGNIT & FLASH BACK. KEEP CNTNRS TIGHTLY CLSD. ISOLATE
FROM (SUPDAT)

Spill Release Procedures:EVACUATE AREA, REMOVE ALL SOURCES OF IGNIT &
VENTILATE WELL. CNTN SPILLED LIQ W/SAND OR EARTH. DO NOT USE
COMBUST MATLS SUCH AS SAWDUST. REMOVE ALL SOURCES OF IGNIT,
VENTILATE AREA & REMOVE W/INERT AB SORB & NON-SPARKING TOOLS.
DISPOSE OF ACCORDING TO LOCAL, STATE (PROVINCIAL) & FEDERAL REGS.
DO NOT INCINERATE CLOSED CONTAINERS.

Handling and Storage Precautions:WASH THOROUGHLY AFTER HANDLING. WASH
HANDS BEFORE EATING. USE ONLY IN WELL-VENTILATED AREA. FOLLOW ALL
MSDS/LABEL PRECAUTIONS EVEN AFTER CONTAINER IS EMPTIED BECAUSE IT
MAY RETAIN PRODUCT RESIDUES. AV OID BREATHING VAPOR OR MIST. KEEP
CONTAINERS CLOSED.
Other Precautions:ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS &
OPEN FLAME. DO NOT STORE ABOVE 200 DEGREES F. STORE LG QTYS IN
BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA CLASS I
FLAMMABLE LIQUIDS. CONTENTS UNDER PRESSURE. DO NOT EXPOSE TO HEAT
OR STORE ABOVE 120 DEGREES F.

Respiratory Protection:A RESP PROT PROGRAM THAT MEETS OSHA 1910.134 &
ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CNDTNS
WARRANT RESP'S USE. A NIOSH APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE/CANISTER MAY BE PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES
WHERE AIR CONCS ARE EXPECTED TO EXCEED EXPOS LIMITS. USE NIOSH
APPRVD POS PRESS AIR SUPPLIED RESP (SUPDAT)
Ventilation:USE PROCESS ENCLOSURES, LOC EXHST VENT/OTHER ENGINEERING
CTLS TO CTL AIRBORNE LEVELS BELOW REC EXPOS LIMITS. USE EXPLO-PROOF
VENT EQUIP. PVNT (OTHER INFO)
Protective Gloves:IMPERVIOUS GLOVES TO PVNT SKIN CONT & ABSORP OF THIS
(OTHER INFO)
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
REFER TO SFTY SUPERVISOR/INDUSTRIAL HYGIENIST FOR FURTHER INFO
REGARDING PERSONAL PROT EQUIPMENT & ITS APPLICATION.
Work Hygienic Practices:WASH THOROUGHLY WITH SOAP AND WATER BEFORE
EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ: HEAT, ELEC EQUIP, SPKS & OPEN FLAME. PERFORATION OF
PRESSURIZED CNTNR MAY CAUSE BURSTING OF CAN. CLSD CNTNRS MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT. RESP PROT: IF THERE IS ANY
POTNTL FOR UNCONTROLLED RELEASE, EXPOS LEVELS ARE NOT KNOWN, OR
ANY OTHER CIRCUMSTANCES WHERE NIOSH APPRVD (OTHER INFO)

Boiling Pt:>-42.2C, -44.F
B.P. Text:-44 - 420F
Vapor Density:HVR/AIR
Spec Gravity:1.2296
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
Stability Condition to Avoid:AVOID TEMPERATURES ABOVE 120F. AVOID ALL
POSSIBLE SOURCES OF IGNITION.
Hazardous Decomposition Products:BY OPEN FLAME, CARBON MONOXIDE AND
CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL,
STATE AND FEDERAL REGULATIONS AND ORDINANCES. DO NOT ALLOW TO ENTER
STORM DRAINS OR SEWER SYSTEMS.

Toxicological Information:XYLENE: LD50: RAT 4300 MG/KG. LC50: RAT
6000PPM 4 HR. TOLUENE: LD50: RAT 5000 MG/KG. LC50: MOUSE 5320 PPM 8
HR. N-BUTANE: LD50: RAT 658 G/M
3 4 HR. AROMATIC SOLVENT: LD50: 4900 MG/KG (RAT). DIPROPYLEN E GLYCOL:
LD50: RAT 14850 MG/KG.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:PRODUCT IS A MIXTURE OF LISTED COMPONENTS.

Transport Information:NO TRANSPORTATION INFORMATION IS AVAILABLE.

SARA Title III Information:THIS PROD HAS BEEN REVIEWED ACCORDING TO EPA
"HAZARD CATEGORIES' PROMULGATED UNDER SECTIONS 313 OF TITLE III OF
SUPERFUND AMENDMENTS & REAUTHORIZATION ACT OF 1986 & 40 CFR PART
372.
Federal Regulatory Information:OSHA: HAZARDOUS BY DEFINITION OF HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200). INTERNATIONAL
REGULATIONS: AS FOLLOWS - CANADIAN WHMIS: THIS MSDS HAS BEEN
PREPARED IN COMPLIANCE WITH CONTROLLED PRO DUCT REGULATIONS EXCEPT
FOR USE OF THE 16 HEADINGS. CANADIAN WHMIS CLASS: NO INFORMATION
AVAILABLE.
State Regulatory Information:NEW JERSEY RIGHT-TO-KNOW: FOLLOWING MATLS
ARE NON-HAZ, BUT ARE AMONG TOP 5 COMPONENTS IN THIS PROD: ALKYD
RESIN SOLUTION CAS# 66070-60-8 & IRON OXIDE #1309-37-1.
PENNSYLVANIA RIGHT-TO-KNOW: FOLLOWING NON-HAZ INGREDS ARE PRESENT
IN PROD @ >3%: ALKYD RESIN SOLUTION & IRON OXIDE. CALIFORNIA PROP
65: WARNING: CHEM(S) NOTED BELOW & CNTND IN PROD, ARE KNOWN TO ST
OF CALIFORNIA TO CAUSE CANCER, BIRTH DEF ECTS OR THER REPRODUCTIVE
HARM: TOLUENE CAS #108-88-3.